• Welcome Visitor! Please take a few seconds and Register for our forum. Even if you don't want to post, you can still 'Like' and react to posts.

Need your opinion on some rust repair


Pix3L8

Well-Known Member
Supporting Member
Joined
Jun 13, 2016
Messages
134
City
Connecticut
Vehicle Year
1989
Engine
2.9 V6
Transmission
Manual
Total Lift
6
Ok guys quarantines got me going over my truck with a fine tooth comb trying to fix everything I can. I’ve had some rust in my back floor for a while but never did anything about it. I’ve got some rust cancer right in the back right corner of the cab (Bronco ii) right around the passenger side tail lamp. I’ve got a full welding setup so that’s not an issue, what I’m struggling with is going about this patch job. It’s right near my gas tank so before I spark up I need to drop the tank but the location is difficult to get a welding torch into. I thought possibly welding in some patches for structure and just fiber glassing the whole thing? Or if I want to weld the whole patch possibly undoing my body mounts and bringing the body up a few inches to get more clearance which is pretty involved but might be necessary to get solid welds. I’m replacing the whole carpet so I want to fix up my floor perfectly before I lay down new carpet. In the two pictures you can see the rust from the back corner and a shot from underneath. I’ve done a lot of sheet metal repairs on the truck but nothing in as tight a space as this.
just looking for suggestions
 

Attachments

  • 81813483-3742-41A2-9B59-402DC7CF6BE5.jpeg
    81813483-3742-41A2-9B59-402DC7CF6BE5.jpeg
    162.1 KB · Views: 189
  • 4D0CA02C-F813-4912-8A42-A7321A5A3D65.jpeg
    4D0CA02C-F813-4912-8A42-A7321A5A3D65.jpeg
    264.3 KB · Views: 186
If you can do it, it fits, and you don't mind the look, you could just do a scab patch with metal sandwiching the bad section after it's been cleaned up. Clean the crap out of the surface and install the patch panel(s) with RTV and install whatever fasteners you choose to use wet to seal the fastener holes.
 
If you can do it, it fits, and you don't mind the look, you could just do a scab patch with metal sandwiching the bad section after it's been cleaned up. Clean the crap out of the surface and install the patch panel(s) with RTV and install whatever fasteners you choose to use wet to seal the fastener holes.
It’s not really a “structural” point in the body so it just needs to be closed not reinforced much.
 
Yup, has Corrodedvirus, quarantine for six months.
 

Sponsored Ad


Sponsored Ad

TRS Events

Member & Vendor Upgrades

For a small yearly donation, you can support this forum and receive a 'Supporting Member' banner, or become a 'Supporting Vendor' and promote your products here. Click the banner to find out how.

Recently Featured

Want to see your truck here? Share your photos and details in the forum.

Ranger Adventure Video

TRS Merchandise

Follow TRS On Instagram

TRS Sponsors


Sponsored Ad


Sponsored Ad


Amazon Deals

Sponsored Ad

Back
Top