-
Welcome Visitor! Please take a few seconds and Register
for our forum. Even if you don't want to post, you can still 'Like' and react to posts.
98 ford ranger Chevy 350 swap
- Thread starter max07
- Start date
None as far as I know
Most Fords used Borg Warner(BW) transfer cases, but Borg Warner transfer cases were also used on GM but had different model numbers, seen here: https://www.f150hub.com/drivetrain/borgwarner-id.html
Different model number usually means different input spline count and bolt pattern
GM tended to used New Process(NP) transfer cases, and Ford did use these as well, an NP205 was used in both Fords and GMs but I believe that have different input shafts
Most Fords used Borg Warner(BW) transfer cases, but Borg Warner transfer cases were also used on GM but had different model numbers, seen here: https://www.f150hub.com/drivetrain/borgwarner-id.html
Different model number usually means different input spline count and bolt pattern
GM tended to used New Process(NP) transfer cases, and Ford did use these as well, an NP205 was used in both Fords and GMs but I believe that have different input shafts
- Joined
- Feb 15, 2020
- Messages
- 6,597
- City
- Southern maine
- State - Country
- ME - USA
- Vehicle Year
- 1996
- Vehicle
- Ford Ranger
- Drive
- 2WD
- Engine
- 2.3 (4 Cylinder)
- Transmission
- Manual
- Total Drop
- Shackle flip
- Tire Size
- 235/60/15
- My credo
- Its probably better to be self deprecating than self defecating.
..why not just use a gm transfer case?
Because Gm used passenger side drop instad of driver and I’m on a tight budget but have Chevy th350 trans and Chevy 350 motor but have a ranger that I want to v8 swap
bobbywalter
TRS Technical Staff
TRS Event Staff
V8 Engine Swap
TRS Technical Advisor
TRS 20th Anniversary
Ugly Truck of Month
TRS Event Participant
TRS 25th Anniversary
- Joined
- Aug 9, 2007
- Messages
- 25,080
- City
- woodhaven mi
- Vehicle Year
- 1988
- Engine
- Transmission
- Automatic
- Total Lift
- sawzall?
- Tire Size
- 33-44
- My credo
- it is easier to fix and understand than "her"
What axle.???.
.if your pumpkin is on the dumb side of the truck...use the Chevy dumb side t case...
.if your pumpkin is on the smart side of the truck...use a Chevy 241 t case with the wormy ass 27 spline input for the th350
From there ..get a clocking ring and you can use the jeep which is best...or ford 208 with the 27 spline input shaft from the Chevy swapped in.
Unless you want a 205. . Same deal. Ford unit .. Chevy input
.if your pumpkin is on the dumb side of the truck...use the Chevy dumb side t case...
.if your pumpkin is on the smart side of the truck...use a Chevy 241 t case with the wormy ass 27 spline input for the th350
From there ..get a clocking ring and you can use the jeep which is best...or ford 208 with the 27 spline input shaft from the Chevy swapped in.
Unless you want a 205. . Same deal. Ford unit .. Chevy input
- Joined
- Nov 13, 2018
- Messages
- 4,988
- City
- Canaan
- State - Country
- NH - USA
- Vehicle Year
- 1993
- Vehicle
- Ford Ranger
- Drive
- 2WD
- Transmission
- Automatic
- Total Drop
- 3"
- Tire Size
- 235/55R16
- My credo
- If you don't have time to do it right will you have time to do it over?
Nevermind. I thought someone was willing to swap you a Ranger for a grenade/SBC and I was going to say grab it before he sobers up.
- Joined
- Feb 11, 2021
- Messages
- 2,942
- City
- Seattle, WA
- Vehicle Year
- 1991
- Engine
- 3.0 V6
- Transmission
- Automatic
- My credo
- Keep your mind like an umbrella, it only works if its open... Continually learning.
I would have to double check, but I believe I have an extra 241C dr. side drop you could have. I stole the short yoke off of it. Shipping would probably be more than buying one local to you though.
bobbywalter
TRS Technical Staff
TRS Event Staff
V8 Engine Swap
TRS Technical Advisor
TRS 20th Anniversary
Ugly Truck of Month
TRS Event Participant
TRS 25th Anniversary
- Joined
- Aug 9, 2007
- Messages
- 25,080
- City
- woodhaven mi
- Vehicle Year
- 1988
- Engine
- Transmission
- Automatic
- Total Lift
- sawzall?
- Tire Size
- 33-44
- My credo
- it is easier to fix and understand than "her"
I have them.
But I need them
But I need them
What state you located at
- Joined
- Feb 11, 2021
- Messages
- 2,942
- City
- Seattle, WA
- Vehicle Year
- 1991
- Engine
- 3.0 V6
- Transmission
- Automatic
- My credo
- Keep your mind like an umbrella, it only works if its open... Continually learning.
Washington.
Similar threads
Sponsored Ad
Sponsored Ad
TRS Events
Member & Vendor Upgrades
For a small yearly donation, you can support this forum and receive a 'Supporting Member' banner, or become a 'Supporting Vendor' and promote your products here. Click the banner to find out how.
Latest posts
-
-
-
For Sale 2003 Ranger 3.0 lots of parts brand new in packing.- Latest: PrerunRanger02
-
-
2.3L ('83-'97) '97 crank, no start, has fuel, but no spark
- Latest: Broke College Student
-
-
Recently Featured
Ranger Adventure Video
TRS Merchandise
Follow TRS On Instagram
