• Welcome Visitor! Please take a few seconds and Register for our forum. Even if you don't want to post, you can still 'Like' and react to posts.

82 Ford E-150 Fuel Gauge Problem


Jim Oaks

Jim Oaks

Just some guy with a website
Administrator
Founder / Site Owner
Supporting Vendor
Article Contributor
TRS Banner 2010-2011
TRS Banner 2012-2015
TRS 20th Anniversary
VAGABOND
TRS Event Participant
GMRS Radio License
Joined
Aug 2, 2000
Messages
13,468
Reaction score
8,645
Points
113
Location
Nocona, Texas
Vehicle Year
1996 / 2021
Make / Model
Ford Ranger
Engine Type
4.0 V6
Engine Size
4.0 / 2.3 Ecoboost
Transmission
Automatic
2WD / 4WD
4WD
Total Lift
6-inches
Tire Size
33x12.50x15
The fuel gauge in my '82 Ford E-150 van quite working. It has a dual tank setup, and both tanks work, but I think the gauge quit working when I switched from the rear to front tank.

I ran a jumper from the sending units ground wire to the frame to make sure it was grounded. Gauge still didn't work. Unless it's a connection in the switch, I can't figure out the problem. A faulty fuel gauge is usually a ground problem.

This is the metal toggle switch under the dash style.

Anyone have any experience with this?
 


Jim Oaks

Jim Oaks

Just some guy with a website
Administrator
Founder / Site Owner
Supporting Vendor
Article Contributor
TRS Banner 2010-2011
TRS Banner 2012-2015
TRS 20th Anniversary
VAGABOND
TRS Event Participant
GMRS Radio License
Joined
Aug 2, 2000
Messages
13,468
Reaction score
8,645
Points
113
Location
Nocona, Texas
Vehicle Year
1996 / 2021
Make / Model
Ford Ranger
Engine Type
4.0 V6
Engine Size
4.0 / 2.3 Ecoboost
Transmission
Automatic
2WD / 4WD
4WD
Total Lift
6-inches
Tire Size
33x12.50x15
Man. Now I'm not sure if it's even switching tanks. It has a solenoid on the frame rail with a line from each tank coming in, and one going up to the manual fuel pump on the block. It clicks when you flip the switch to change tanks.

The switch also controls which gauge is read. I haven't found a replacement if it's bad.
 

RonD

Official TRS AI
TRS Technical Advisor
Joined
Jun 2, 2012
Messages
25,363
Reaction score
8,369
Points
113
Location
canada
Vehicle Year
1994
Make / Model
Ford
Transmission
Manual
The fuel valve is a simple 12volt on/off valve, 0volt = tank 1, 12volt = tank 2

Google: Universal Fuel Tank Switch

If you have a mechanical fuel pump and carb then the Dual Tank switch in the cab will just be a double throw double pole switch.
This is in essence two separate switches controlled by one "lever"

The fuel gauge is connected to a pulsed 5volt regulator, this power passes thru the gauge to the sender in the tank which is a variable resistor and then to a Ground.

Battery-----Pulsed 5v-------Gauge-----sender----ground

For dual tanks is would look like this:
Battery-----Pulsed 5v-------Gauge-----Switch----sender 1----ground
....................................................................\---sender 2----ground

So the switch will have 3 "gauge" wires, 1 coming from the gauge, 1 from each sender.

You can't measure pulsed voltage, but if you hook up a test light it should go on and off with key on.
You can measure OHMS on the Sender wires, pre-'89 Fords use this range:
73-10 Ohms
73 = Empty
10 = Full

If you hook up an OHM meter to one sender wire and then add some fuel to each tank you can tell which is which, or look at the wire color.

If OHMs on one stay at around 73 then that float is no longer a "float", it is a "sink", lol.

So the Double Pole Double Throw switch will have 3 contacts on one side and 3 contacts on the other side.
Each set of 3 are separate, no internal connection.
On one set you will have just 2 wires, one will have 12v when key is on(center pin), the other one will run to the Fuel valve.
So when switch is push one way Fuel valve will get 12volts, pushed the other way Fuel valve gets 0volts.

Other set of 3 will have 3 wires, center pin will be from Fuel Gauge, then each sender wire to one of the outside pins
 
You must log in or register to reply here.

Sponsored Ad


Sponsored Ad

Staff online

Members online

Total: 452 (members: 6, guests: 446)

Today's birthdays

Member & Vendor Upgrades

For a small yearly donation, you can support this forum and receive a 'Supporting Member' banner, or become a 'Supporting Vendor' and promote your products here. Click the banner to find out how.

Latest posts

Truck of The Month


Shran
April Truck of The Month

Recently Featured

Want to see your truck here? Share your photos and details in the forum.

Follow TRS On Instagram

Latest Album Photos

20240409_190831.jpg
20240409_190818.jpg
20240409_180824.jpg
20240409_182648.jpg
20240409_181010.jpg
20240408_175026.jpg
99 Ranger
20200706_161414.jpg
20240207_155117.jpg
20240207_155111.jpg
20240207_154537 - Copy.jpg
20240207_154500 - Copy.jpg

TRS Events

25th Anniversary Sponsors

Check Out The TRS Store


Sponsored Ad


Sponsored Ad

Sponsored Ad


Amazon Deals

Top